2.0-liter diesel engines for the car Skoda Kodiaq 1

2.0L Diesel Engine — technical data
Main technical characteristics Engine codes DFGA Emission standards EU6 Engine capacity 1.968 Power, at rpm 110/3500-4000 Torque, at rpm 340/1750 -3000 Inner diameter of cylinder, mm 81.0 Full piston stroke, mm 95.5...

Poly V-belt for accessory drive
General appearance 1. Poly V-belt for drive of accessory equipment; 2. Mounting bolt, tightening torque during installation 10 Nm + tighten additionally by an angle of 90°; 3. Crankshaft pulley; 4. Attachment drive belt...

Attachment drive belt
Removal and installation Removal 1. Remove the soundproofing covering from the engine compartment. Caution: If the accessory drive belt is to be reused, an arrow indicating the direction of rotation must be drawn on its...

Compression check
Note: To perform the following tasks, it is necessary to use special devices, control and measuring instruments, as well as auxiliary means: Hinged wrench No. 10(3220). Compression pressure measuring device, eg (VAG...

Gas distribution mechanism drive belt covers
General appearance 1. Lower cover of the timing belt; 2. Fastening screw, tightening torque during installation 12 Nm; 3. Mounting bracket; 4. Fastening bolt, tightening torque 5 Nm; 5. Branch pipe; 6. Retainer; 7....

Gas distribution mechanism drive belt
General appearance 1. Mounting bolt, tightening torque during installation 180 Nm + tighten additionally by an angle of 135°; 2. Crankshaft toothed pulley - timing drive; 3. Fastening nut, tightening torque during...

Upper cover of the timing belt
Removal and installation Removal 1. Remove the upper decorative engine cover assembly. Models with SCR system 2. Disconnect the wiring harness connector, then remove the agent injection nozzle (5). 3. Release the wiring...

Lower cover of the timing belt
Removal and installation Removal Note: To simplify the assembly process on the assembly line, the lower timing belt cover is installed together with the guide, which is installed in the flange of the front crankshaft...

Gas distribution mechanism drive belt
Removal and installation Removal the timing belt from the camshaft sprocket 1. Remove the upper timing belt cover ( for more details, see the relevant section in this chapter ). 2. Remove the crankshaft pulley ( for...

Cylinder head cover
General appearance 1. Sealing gasket; 2. Cylinder head cover; 3. Sealing ring; 4. Plug; 5. Bracket; 6. Fastening screw, tightening torque during installation 8 Nm; 7. Rubber bushing; 8. Clamp; 9. Mounting bolt; 10....

Cylinder head assembly
General appearance 1. Cylinder block assembly; 2. Cylinder head gasket; 3. Cylinder head assembly; 4. Mounting pin; 5. Mounting bolt; 6. Mounting bolt, tightening torque during installation 20 Nm; 7. Eye for hanging the...

Gas distribution mechanism
General appearance 1. Mounting bolt; 2. Hall sensor; 3. Sealing ring; 4. Lid; 5. Camshaft sealing cuff; 6. Camshaft housing; 7. Mounting bolt; 8. Sealing ring; 9. Lid; 10. Fastening bolt, tightening torque: 8 Nm; 11....

Crankshaft — components
Crankshaft 1. Cylinder block; 2. Bearing insert, upper (in the cylinder block); 3. Crankshaft toothed pulley; 4. Crankshaft main bearing shell (in the main bearing cap); 5. Bolt for fastening the crankshaft main bearing...

Connecting rod and piston group
1. Connecting rod cap mounting bolt, tightening torque during installation 30 Nm + tighten additionally by an angle of 90; 2. Connecting rod cover; 3. Crankpin bearings; 4. Connecting rod; 5. Retaining ring; 6. Piston...

Checking the piston protrusion above the cylinder block surface
Note: When setting the piston to TDC, it is necessary to measure its protrusion above the cylinder block joint plane using a dial indicator with special stands. 1. Attach the piston protrusion measuring device (MP...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Read similar sections on other Skoda models

➧ Power unit: Diesel engines Skoda Rapid 1 (2012-2022)
➧ Power unit: Diesel engines 1.9 l Skoda Superb 2 (2008-2015)
➧ Power unit: Diesel engine 2.0 l Skoda Yeti (2009-2017)
➧ Power unit: Diesel engine Skoda Felicia (1994-2001)

Link to this section in various formats

TEXTHTMLBB Code

Kodiaq 1 (2016-2024)