ECM Engine Model
- 1.4 l SAHA — Bosch Motronic MED 05/17/20
- 1.8 and 2.0 l BZB, CDAA, CDAB and CCZA - Bosch Motronic MED 17.5
- 3.6 l CDVA - Bosch Motronic MED 9.1
- 1.6 l CAYC - Bosch EDC 17 CP 14
- 1.9 l BXE, BLS - Bosch EDC 15P+ or EDC 16
- 2.0 l BMP, BKD - Bosch EDC 16
- 2.0L CBBB - Bosch EDC 17
- 2.0 l CFFB, CLJA, CFGB - Bosch EDC 17 C 46
Cylinder firing order
- 4-cylinder models - 1-3-4-2
- 6-cylinder models (3.6 l)¹ — 1-4-3-6-2-5
Length of generator brushes, mm
- New - 12
- Wear limit - 5
Maximum permissible difference in the length of the generator brushes, mm - 1
Battery type: 12-volt, maintenance-free
Tightening force, Nm
- Nuts for clamps for fastening electrical wiring to the battery - 6
- Battery hold-down bolt - 22
- Battery Holder Fastener - 9
- Spark plugs - 30
- Nuts M10 // M12 starter mounting - 40 // 80
- Copper // steel nut for fastening the positive wire to the starter - 16 // 20
- Negative cable mounting nut on starter - 20
- Starter Wiring Holder Nut - 23
- Generator Wiring Holder Nut - 3.2
- Self-locking nut for fastening the B+ wire to the generator - 20
- Generator mounting bolts - 23
¹ Cylinder counting starts from the auxiliary drive side (not from the timing drive side) and goes in a checkerboard pattern.
Spark plugs
EOBD diagnostic codes
P0000 No fault codes in system memory
P0030 Open in pre-catalytic lambda probe heating circuit
P0031 Low Voltage in Pre-Catalytic Lambda Probe Heating Circuit
P0032 Pre-Catalytic Lambda Probe Heating Circuit Voltage Too High
P0036 Post-Catalytic Lambda Probe Heating Circuit Open
P0037 Post-Catalytic Lambda Probe Heater Circuit Low Voltage
P0038 Post-Catalytic Lambda Sensor Heater Circuit High Voltage
P0053 Pre-catalytic lambda probe heater resistance out of tolerance
P0054 Post-Catalytic Lambda Probe Heater Resistance Out of Limits
P0071 Malfunction in the cabin air temperature sensor circuit
P0106 Absolute Pressure (MAP) Sensor/Barometric Pressure Sensor Malfunction
P0107 Short to Ground in MAP Sensor/Barometric Pressure Sensor Circuit
P0108 Open or short to positive in MAP sensor / atmospheric pressure sensor circuit
P0109 MAP Sensor/Barometric Pressure Sensor Intermittent Malfunction
P0112 Short to Ground in IAT Sensor Circuit
P0113 Open or short to positive in IAT sensor circuit
P0114 IAT Sensor Intermittent Malfunction
P0115 Engine Cooling System Signal Error
P0116 ECT Sensor Input Too Low/Engine Output Performance Problems
P0117 Short to Ground in ECT Sensor Circuit
P0118 Open or short to positive in the ECT sensor circuit
P0119 ECT Sensor Intermittent Malfunction
P0122 TPS Sensor/Accelerator Pedal Position Sensor A Circuit #1 Short to Ground
P0123 Open or Short to Positive in TPS Sensor/Accelerator Pedal Position Sensor A Circuit #1
P0130 Pre-catalytic lambda probe circuit open
P0131 Short to Ground in Pre-Catalytic Lambda Probe Circuit
P0132 Short to positive in pre-catalytic lambda probe circuit
P0133 Pre-Catalytic Lambda Sensor Slow Response
P0134 Pre-Catalytic Lambda Sensor Low Amplitude
P0136 Post-Catalytic Lambda Probe Circuit Open
P0137 Short to Ground in Post-Catalytic Lambda Probe Circuit
P0138 Short to positive in post-catalytic lambda probe circuit
P0139 Post-Catalytic Lambda Sensor Slow Response
P0171 Air-Fuel Ratio Too Lean, NOX Emissions
P0172 Air/fuel mixture too rich, HC/CO emissions
P0201 - P0204 Malfunction in the injector circuit of cylinders 1 - 4 respectively
P0222 TPS/Sensor Switch B Circuit #2 Short to Ground
P0223 Short to Positive in TPS/Sensor Switch B Circuit #2
P0231 Fuel Pump Input Voltage Low
P0232 Fuel Pump Output Voltage Low
P0236 Turbocharger Boost Pressure Sensor Circuit Range/Performance
P0237 Turbocharger Boost Pressure Sensor Circuit Low Input Voltage
P0238 Turbocharger Boost Pressure Sensor Circuit High Input Voltage
P0243 Turbocharger Boost Control Valve Operation Problem
P0261/P0262 Injector 1 Circuit Low/High Voltage
P0264/P0265 Injector 2 Circuit Low/High Voltage
P0267/P0268 Injector 3 Circuit Low/High Voltage
P0270/P0271 Injector 4 Circuit Low/High Voltage
P0300 Random misfires occur on various cylinders
P0301-P0304 There are misfires in cylinders 1 - 4 respectively
P0315 CKP Sensor Not Recognized
P0324 Knock Sensor Communication Error or KS Signal Abnormal
P0325 KS signal abnormal
P0335 Crankshaft Position Sensor Abnormal Signal
P0336 Timing Problem or No Signal from CKP Sensor
P0340 No signal from the CMP sensor
P0341 Abnormal Signal from the CMP Sensor
P0351/P0352 Ignition Coil A/B Primary Circuit Malfunction
P0404 EGR Valve Malfunction
P0420 Catalytic Converter Low Efficiency
P0444 EVAP Canister Purge Control Valve Circuit Open
P0458 EVAP Canister Purge Control Valve Circuit Short to Ground
P0459 EVAP Canister Purge Control Valve Circuit Short to Positive
P0460 Fuel Level Sensor Circuit Malfunction, Instrument Cluster
P0460-15 Short to positive or open in fuel level sensor circuit
P0462-00 Short to Ground in Fuel Level Sensor Circuit
P0500 VSS Sensor Signal Is Unstable or Abnormal
P0503 VSS Sensor Signal Too High
P0511 Idle Speed Control Circuit Malfunction
P0560 On-Board Electrical System Voltage Too High
P0562 Open in the On-Board Electrical System Circuit
P0563-00 Charging system faulty
P0571 Brake Pedal Position Sensor Intermittent Malfunction
P0603 Memory Regeneration Error (NV or EEPROM) control module
P0604 Control Module RAM Error
P0605 Control module ROM checksum error
P0610 Vehicle Identification Module (VID) Checksum Incorrect and Unprogrammed
P0617 Starter Relay Circuit Malfunction
P0620 Generator Circuit Malfunction
P0625 Generator Low Voltage
P0626 Generator Voltage High
P0628 Fuel Pump Primary Circuit Short to Ground
P0629 Short to positive in fuel pump primary circuit
P0641 Noise in Power Supply Signal #1 to Transmission Sensor
Information presented on the website [SkodaBook.ru]
P0642 Transmission Sensor Power Supply Signal #1 Low Voltage
P0643 Transmission Sensor Power Supply Signal #1 High Voltage
P0646 Air Conditioning Compressor Clutch Relay Short to Ground
P0647 Short to positive in the air conditioning compressor clutch relay circuit
P0651 Noise in Power Supply Signal #2 to Transmission Sensor
P0652 Transmission Sensor Power Supply Signal #2 Low Voltage
P0653 Transmission Sensor Power Supply Signal #2 High Voltage
P0654 Engine Speed Output Circuit Malfunction
P0686 Main Relay Circuit Short to Ground
P0687 Short to positive in main relay circuit
P0691 Cooling Fan 1 Control Circuit Short to Ground
P0692 Short to positive in the control circuit of the cooling system fan 1
P0693 Cooling Fan 2 Control Circuit Short to Ground
P0694 Short to positive in the control circuit of the cooling system fan 2
P0704 Clutch Pedal Position Sensor D/V Signal Unstable
P0722 No signal from VSS sensor
P0727 Current Engine Speed Error