Fuel system (diesel, 1.4 l) of car Skoda Fabia 2

Fuel tank with installed parts
Fuel tank with installed parts 1 - Cork; 2 - Seal; 3 - Fuel tank filler cap module, with dust cover; 4 - Gravity valve, to remove, release the valve from the clamps by pulling it upwards, check the valve capacity: valve...

Removal and installation the fuel tank
Unscrew the fuel tank filler cap. Fold the right rear seat upright. Remove the fuel pump cover under the carpet. Disconnect the four-pin fuel pump connector. Empty the fuel tank. Remove the middle and rear sections of...

Removal and installation the fuel pump
The fuel tank must be filled to a maximum of 3/4 full. The ignition must be turned off and the key must be removed from the ignition switch. Fold the right rear seat upright. Remove the fuel pump cover under the carpet....

Removal and installation the fuel gauge sensor «G»
Remove the fuel pump. Important: When installing, ensure that the wire terminals are correctly positioned. Release the retaining tabs of wiring connectors "3" and "4" and remove them. Using a screwdriver, lift retaining...

Removal and installation a tandem pump
Caution: The tandem pump must not be disassembled, as this may cause the vacuum portion of the pump to not function properly. The consequence would be failure of the brake booster. Remove the supply hose "1" (with white...

Turbocharger, supercharger
Removal and installation a turbocharger with installed parts for engines with letter designations BNM, BNV 1 - Exhaust manifold, with turbocharger, replace only as a set; 2 - Intake gas pipeline; 3 - From the charge air...

Removal and installation the charge air cooler
Remove the right front wheel arch (fender) liner. Remove the front bumper. For engines with letter designations BNM, BNV Disconnect plug connector "1" from boost pressure sensor "G71" with intake air temperature sensor...

Removal and installation a turbocharger for an engine with the letter designation BMS
Remove the front exhaust manifold with the particulate filter from the turbocharger. Remove the air intake hose from the turbocharger connection pipe and air filter. Remove the front wall air duct and air filter. Remove...

Fuel supply of a diesel engine
Assembly location diagram for engines with letter designations BNM, BNV Parts marked with letters A through H are not shown on the assembly location diagram. A - Direct fuel injection system relay. diesel engine "J322",...

Removal and installation the air filter
After releasing the spring clamp "1" on the air hose, remove the hose from the air filter. After removing the air bleed hose "2", disconnect the plug connector on the air flow meter "3". Remove the air line "4" from the...

Repair of pump-injector units
Important: Always replace the thermal insulation sealing rings and O-rings. Screws that are additionally tightened by the angle of rotation must always be replaced. 1 - 20 Nm + turn 1/4 turn (90°), replace; 2 - Rocker...

Engine control unit
Removal and installation the engine control unit "J623" Important: If the engine control unit is to be replaced correctly, the VAS 5051 must be connected and the "Replace Engine Control Unit" function must be performed....

Exhaust system
Assembly diagram for engines with letter designations BNM, BNV 1 - Seal, replace; 2 - 25 Nm, replace, lubricate studs with paste for connections subject to thermal stress "G 052 112 A3"; 3 - Spring suspension, replace...

Removal and installation the front section of the exhaust pipe with a particulate filter
Remove the upper engine cover. Remove the charge air pipe to the right. Remove the intake manifold flap motor "V157". Remove the EGR valve "N18" with the EGR potentiometer "212" and the EGR regulator "V338". Disconnect...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Read similar sections on other Skoda models

➧ Power unit: Power and control system Skoda Rapid 1 (2012-2022)
➧ Power unit: Fuel system Skoda Octavia 1 (1996-2004)
➧ Power unit: Power and exhaust system Skoda Superb 2 (2008-2015)
➧ Power unit: Power and control system Skoda Yeti (2009-2017)
➧ Power unit: Diesel power system Skoda Felicia (1994-2001)

Link to this section in various formats

TEXTHTMLBB Code

Fabia 2 (2007-2014)